Product ID:M-O-NC BLACK, ME1009
MSDS Date:10/20/1997
FSC:7510
NIIN:01-341-1006
Status Code:A
Kit Part:Y
MSDS Number: CJMZR

DEXTER ELECTRONIC MATERIALS

15051 EAST DON JULIAN ROAD
INDUSTRY, CA 91746
US

Emergency Phone: 626-916-9107

Info Phone: 626-968-6511

Cage: 12405

DEXTER CORP DEXTER ELECTRONIC MATERIALS DIV

LA PUENTE, CA 91746 US

Telephone: 818-968-6511

Cage: 12405

EPOXY RESIN (MFR INVALID CAS NO. 25058-38-6)

OSHA PEL N/K

ACGIH TLV: N/K

BISPHENOL A

CAS: 80-05-7

RTECS: SL6300000

OSHA PEL N/K

ACGIH TLV: N/K

DIETHYLENE GLYCOL ETHYL ETHER ACETATE; (DIETHYLENE GLYC ETH

CAS: 112-15-2

RTECS: KK8925000

OSHA PEL N/K

ACGIH TLV: N/K

C.I. PIGMENT BLACK 28; (BLACK PIGMENT)

CAS: 68186-91-4

OSHA PEL N/K

ACGIH TLV: N/K

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: MODERATELY IRRITATING WITH
REDNESS, PAIN OR TEARING. PROLONGED CONTACT MAY CAUSE BURNS. SKIN:
SLIGHTLY IRRITATING. FREQUENT OR PROLONGED CONTACT MAY IRRITATE AND
CAUSE A RASH (DERMATITIS). REPEA TED EXPOSURE MAY CAUSE ALLERGIC
SKIN REACTIONS. ONCE AN ALLERGY DEVELOPS, EVEN AN EXPOSURE TO A
VERY SMALL AMOUNT CAN TRIGGER AN ALLERGIC REACTION. INHALATION:
SLIGHTLY IRRITATING TO THE EYES, NOSE, T HROAT AN LUNGS. INGESTION:
SLIGHTLY IRRITATING TO THE MOUTH, STOMACH AND DIGESTIVE TRACT. MAY
CAUSE VOMITING. TARGET ORGANS: INGREDIENTS MAY BE TOXIC TO THE
FOLLOWING ORGANS: SKIN, EYES, LUNGS, MUCOUS MEMBRANES.
Explanation of Carcinogenicity:NOT LISTED.
Effects of Overexposure:SEE HEALTH HAZARDS.

First Aid:EYES: FLUSH W/FLOWING WATER FOR AT LEAST 15 MINS. BLINK EYES
FREQUENTLY. REPEAT FLUSHING IF BURNING/PAIN PERSISTS. GET IMMED MED
ATTN. SKIN: RINSE SKIN IMMED W/PLENTY OF WATER. THEN WASH SKIN
IMMED W/ SOAP & WATER. REMOVE CONTAM CLTHG. DO NOT APPLY
LOTIONS/CREAMS W/OUT ADVICE OF MD/POIS CTR. IF PROBLEMS PERSIST GET
PROMPT MED ATTN. INHAL: REMOVE VICTIM TO FRESH AIR. IF BRTHG IS
DFCLT GET IMMED MED ATTN. IF NOT BRTHG GIVE ARTF RESP & CALL FOR
EMER MED ASSIST. INGEST: DO NOT INDUCE VOMIT. RINSE MOUTH W/WATER &
ALLOW PATIENT TO DRINK AS MUCH WATER AS DESIRED. CONT POIS CTL
CTR/GET PROMPT MED ATTN IF SYMPS OF IRRIT PERSIST.

Flash Point Method:SCC
Flash Point:>93.3C, 200.F
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICALS, WATER SPRAY OR
FOG.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:HEAT IN EXCESS OF FLASHPOINT, OPEN FLAME,
OR STORAGE WITH INCOMPATIBLE MATERIALS AS LISTED IN STABILITY AND
REACTIVITY. HAZARDOUS PRODUCTS/COMBUSTION: CARBON MONOXIDE, CARBON
DIOXIDE.

Spill Release Procedures:REMOVE IGNITION SOURCES. PROVIDE ADEQUATE
VENTILATION AND/OR PERSONAL PROTECTIVE EQUIPMENT (SEE CONTROL
MEASURES SECTION). ABSORB SPILL WITH INERT MATERIAL (E.G., DRY SAND
OR EARTH), THEN PLACE IN A C HEMICAL WASTE CONTAINER. PREVENT
RUNOFFTO STORM SEWERS, DITCHES AND OTHER PATHWAYS TO SOIL AND
WATERWAYS.

Handling and Storage Precautions:AVOID BREATHING FUMES. DO NOT SPLASH
OR SPILL. DO NOT STORE WITH INCOMPATIBLE MATERIALS. STORE
CONTAINERS UPRIGHT. KEEP AWAY FROM HEAT AND FLAME.

Respiratory Protection:NO RESPIRATOR IS REQUIRED IF INGREDIENT EXPOSURE
LIMITS ARE NOT EXCEEDED. A NIOSH APPROVED (29 CFR 1910.134 USA
DEPT. OF LABOR), AIR PURIFYING, HALF-FACE RESPIRATOR WITH THE
APPROPRIATE CARTRIDGE SHOU LD BE USED IF EXPOSURE LIMITS ARE
EXCEEDED.
Ventilation:USE LOCAL EXHAUST VENTILATION.
Protective Gloves:WEAR CHEMICAL RESISTANT RUBBER GLOVES.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EYEWASH AND DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . WEAR CHEMICAL RESISTANT RUBBER APRON.
Supplemental Safety and Health
WASTE DISPOSAL METHOD: (2) RECLAMATION, REGENERATION/RECYCLING; (3)
BURNING FOR ENERGY RECOVERY/INCINERATION; (4) TREATMENT. VOC:
27.4%; VOC: 378 G/L; VOC: 3.15 LBS/GAL.

Boiling Pt:>204.7C, 400.5F
Spec Gravity:1.74
Appearance and Odor:BLACK VISCOUS MATERIAL WITH SLIGHT ODOR.

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:EXTREME TEMPERATURES.
Hazardous Decomposition Products:NONE.

Waste Disposal Methods:LEGAL DISPOSITION OF WASTES IS THE
RESPONSIBILITY OF THE OWNER/GENERATOR OF WASTE. APPLIC FED, STATE
&/OR LOC REGS MUST BE FOLLOWED DURING TREATMENT, STOR/DISP OF WASTE
CONTAINING THIS PROD. IT IS REC THAT THE FOLLOWING PRIORITY
HIERARCHY BE USED WHEN SELECTING DISP METH: (1)
REUSE/REINTRODUCTION IN TO PROCESS; (SUP DAT)

Toxicological Information:EYES: CONJ IRRIT & REDNESS. MAY CAUSE CORNEAL
DMG. SKIN: SLIGHTLY IRRITATING. ABSORPTION OF TOX AMTS THRU SKIN IS
UNLIKELY UNDER ORDINARY CNDTNS OF INDUS USE. INHAL: MINOR IRRIT OF
MUC MEMBS & UPPER R ESP TRACT. SYSTEMIC TOXICITY IS VERY UNLIKELY
UNDER ORDINARY CNDTNS OF INDUS USE. GLYCOL ETHER IN THIS PROD DOES
NOT CAUSE ADVERSE EFTS ON MALE/FEMALE REPRO SYS. INGEST: SYSTEMIC
EFTS ARE UNLIKELY UNL ESS TAKEN IN MASSIVE AMTS. ACUTE TOXICITY
DATA: DEXTER IS NOT AWARE OF ANY TOXICITY DATA ON SPECIFIC MIXT OF
CHEM COMPONENTS CONTAINED IN THIS PROD. (OTHER INFO)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:ECOTOXICOLOGICAL INFORMATION: DEXTER HAS NOT CONDUCTED
SPECIFIC STUDIES ON THE ECO TOXICITY OR ENVIRONMENTAL FATE OF THIS
PRODUCT. COMMONLY AVAILABLE DATA ON CERTAIN INGREDIENTS INDICATE
THAT ACUTE OR CHRONIC EFFECTS COULD RESULT FROM UNCONTROLLED
RELEASES TO SOIL, GROUND WATER, STORM WATERS, OR AIR. APPROPRIATE
MEASURES SHOULD BE TAKEN TO PREVENT UNCONTROLLED RELEASES. PROMPT
CONTAINMENT AND CLEA N-UP SHOULD BE PERFORMED IF RELEASES DO OCCUR.

Transport Information:DOT/IATA PROPER SHIPPING NAME: INK MATERIALS.
DOT/IATA HAZARD CLASS: NOT REGULATED. DOT/IATA UN OR NA NUMBER: NOT
REGULATED. DOT/IATA PACKING GROUP: NOT REGULATED. DOT/IATA LABEL:
NOT REGULATED. DOT/I ATA PLACARD: NOT REGULATED.

SARA Title III Information:EPOXY RESIN IS SUBJECT TO THE FOLLOWING:
ENVIRONMENTAL LIST 311/312 SARA PHY/HEA HAZ (40 CFR 370.40).
BISPHENOL A IS SUBJECT TO THE FOLLOWING: ENVIRONMENTAL LIST 311/312
SARA PHY/HEA HAZ (40 CFR 370.4 0); 313 SARA TOXIC CHEM (40 CFR
372.65).DIETHYLENE GLYC ETH IS SUBJECT TO THE FOLLOWING:
ENVIRONMENTAL LIST 311/312 SARA PHY/HEA HAZ (40 CFR 370.40); 313
SARA TOXIC CHEM (40 CFR 372.65). BLACK PIGMENT IS SUBJECT TO THE
FOLLOWING: ENVIRONMENTAL LIST 311/312 SARA PHY/HEA HAZ (40 CFR
370.40).
Federal Regulatory Information:WHMIS HAZARD CLASS: D2B. THIS PRODUCT IS
HAZARDOUS UNDER THE CRITERIA OF THE USA OSHA HAZ COMMUNICATION
STANDARD 26 CFR 1910.1200.